ShanghaiTech University Knowledge Management System
Effect of seeds and sintering additives on (K,Na,Li)NbO3 lead-free single crystals grown by a solid-state crystal growth method | |
2016-04 | |
发表期刊 | JOURNAL OF THE CERAMIC SOCIETY OF JAPAN |
ISSN | 1882-0743 |
卷号 | 124期号:4页码:365-369 |
发表状态 | 已发表 |
DOI | 10.2109/jcersj2.15264 |
摘要 | A solid-state crystal growth (SSCG) method has been utilized to prepare (K0.45Na0.55)(0.94)Li0.06NbO3 (KNLN) lead-free piezoelectric single crystals. The effects of different kinds of seeds and additives on K0.5Na0.5NbO3 (KNN)-based crystal growth were studied. It was found that < 100 >-oriented SrTiO3 seed was inappropriate for growing KNLN single crystal, while < 100 > oriented KTaO3 one could act as a good seed. The inverse pole figure (IPF) showed that the epitaxial layer was indeed single crystal and oriented in the same < 100 > direction as the seed. Addition of 0.5 mol% ZnO, CuO and MnO2 brought liquid phase in the samples and increased the diffusion rate of the atoms. This would finally enhance both the single crystal and the matrix grain growth. Among all the sintering additives, CuO could increase the matrix grain growth remarkably due to the assistance of the largest amount of the Na-deficient liquid phase, whose composition was time-independent. However, CuO was not the most effective one that can promote the single crystal growth. The reasons might be as follows: (1) the liquid accumulation at the interface of the single crystal/matrix lead to the liquid phase content exceeding the critical value in the CuO-added samples, which increased the diffusion distance and partly offset the enhanced diffusion rate; (2) the large matrix grains brought low driving force for crystal growth. (C) 2016 The Ceramic Society of Japan. All rights reserved. |
关键词 | Crystal seed Sintering additives KNN SSCG Single crystal growth |
收录类别 | SCI ; EI |
语种 | 英语 |
资助项目 | CAS/SAFEA International Partnership Program for Creative Research Teams, and Science and Technology Commission of Shanghai Municipality[15ZR1445400] |
WOS研究方向 | Materials Science |
WOS类目 | Materials Science, Ceramics |
WOS记录号 | WOS:000379610100015 |
出版者 | CERAMIC SOC JAPAN-NIPPON SERAMIKKUSU KYOKAI |
EI入藏号 | 20161502228093 |
EI主题词 | Copper oxides ; Crystal growth ; Diffusion ; Grain boundaries ; Grain growth ; Inverse problems ; Liquids ; Matrix algebra ; Niobium oxide ; Sintering ; Sodium |
EI分类号 | Alkali Metals:549.1 ; Chemical Products Generally:804 ; Inorganic Compounds:804.2 ; Algebra:921.1 ; Crystalline Solids:933.1 ; Crystal Growth:933.1.2 |
WOS关键词 | FREE PIEZOELECTRIC CERAMICS ; POTASSIUM-SODIUM NIOBATE ; GRAIN-GROWTH ; LIQUID-PHASE ; KINETICS ; SYSTEM ; CONVERSION ; OXIDE |
原始文献类型 | Article |
引用统计 | |
文献类型 | 期刊论文 |
条目标识符 | https://kms.shanghaitech.edu.cn/handle/2MSLDSTB/1877 |
专题 | 物质科学与技术学院 物质科学与技术学院_特聘教授组_李永祥组 物质科学与技术学院_博士生 |
通讯作者 | Yang, Qunbao |
作者单位 | 1.Chinese Acad Sci, Shanghai Inst Ceram, Key Lab Inorgan Funct Mat & Devices, Shanghai 200050, Peoples R China 2.Univ Chinese Acad Sci, Beijing 100049, Peoples R China 3.ShanghaiTech Univ, Sch Phys Sci & Technol, Shanghai 200031, Peoples R China 4.Australian Natl Univ, Res Sch Chem, GPO Box 4, Canberra, ACT 2601, Australia |
推荐引用方式 GB/T 7714 | Yang, Jie,Fu, Zhengqian,Yang, Qunbao,et al. Effect of seeds and sintering additives on (K,Na,Li)NbO3 lead-free single crystals grown by a solid-state crystal growth method[J]. JOURNAL OF THE CERAMIC SOCIETY OF JAPAN,2016,124(4):365-369. |
APA | Yang, Jie,Fu, Zhengqian,Yang, Qunbao,Li, Yongxiang,&Liu, Yun.(2016).Effect of seeds and sintering additives on (K,Na,Li)NbO3 lead-free single crystals grown by a solid-state crystal growth method.JOURNAL OF THE CERAMIC SOCIETY OF JAPAN,124(4),365-369. |
MLA | Yang, Jie,et al."Effect of seeds and sintering additives on (K,Na,Li)NbO3 lead-free single crystals grown by a solid-state crystal growth method".JOURNAL OF THE CERAMIC SOCIETY OF JAPAN 124.4(2016):365-369. |
条目包含的文件 | 下载所有文件 | |||||
文件名称/大小 | 文献类型 | 版本类型 | 开放类型 | 使用许可 |
修改评论
除非特别说明,本系统中所有内容都受版权保护,并保留所有权利。